Volvo 2003 S80 User Manual

S80 (-06) / XC90SectionGroupWeight(Kg/Pounds)YearMonth887200310S80 (-06) 2002, S80 (-06) 2003, S80 (-06) 2004, S80 (-06) 2005, S80 (-06) 2006, XC90 20

20AD290044920BD8200250Point - applies to the S80 ● Remove the rubber grommet on the cable for the passenger compartment connector socket. ● Cut the to

23M3702529Point - applies to the S80 ● Disconnect the large connector from the accessory electronic module (AEM). First press in the catch (A). Pull t

●Reinstall the cargo compartment carpet●Reinstall the sill trim panel in the rear door●Reinstall the side cushion● Reinstall the seat cushion● Fold th

30R2900268Point - applies to the XC90 ● Remove the junction connector together with the wiring from the underside of the plate underneath the headlamp

34R2900236Point - applies to the XC90 ● Position the wiring and relay on the under side of the plate (1). Position the relay with the side against the

38R8504170Point - applies to the XC90 ●Remove the sill trim panel for the right-hand front door. Pull it off, starting at the front edge, until the cl

41BR8504174Illustration B●Unhook the sill trim panel from the B-post panel. Position the panel in the second/third row of seats.42AR890269142BR8902931

43R8504293Point - applies to the XC90 Applies to cars with two rows of seats● Remove the front storage compartment.44R8504159Point - applies to the XC

47R2000348Point - applies to the XC90 ● Remove the engine splash guard (1) by first removing the screws (2).48R2900253Point - applies to the XC90 ● Ro

50BR2900261● Cut the top off the new rubber grommet (1) ● Insert the cable for the passenger compartment connector socket through the new rubber gromm

Required toolsA0000162A0000163A0000161A0801178D2900454R2900455Installation instructions, accessories - Relay EPH Volvo Car Corporation Göteborg, Swede

53AR370290753BR3703023Point - applies to the XC90 Applies to cars with three rows of seatsIllustration A● Insert a cable (1) at the rear edge of the r

56R3702909Point - applies to the XC90 ● Disconnect the large connector from the accessory electronic module (AEM). First press in the catch (A). Pull

● Reinstall the rear floor hatch(es)● Reinstall the carpet at the front edge of the right-hand side panel ●Reinstall the sill trim panels in the doors

Any comments on this publication? Please contact your nearest dealer. Thank you!Publication no: MA 30664939, Issue: 2003-10Comments:...

INTRODUCTION● NOTE! Read through the entire text before carrying out any work.● The front page gives the date of this edition and the edition it repl

1D2000257Point - applies to the S80 ● Raise the car● Remove the screw (1) from the left air baffle (2) for the front brake● Pull the left air baffle b

5D3601932Point - applies to the S80 ● Lubricate the O-rings on the connectors for the relay and front engine block heater socket. Use low temperature

9D3603398Point - applies to the S80 ● Tighten the single cable for the relay on top of the right front corner of the sub-frame. Tighten the cable toge

13M8503476Point - applies to the S80 ● Remove the seat cushion (1). First pull the front edge of the seat cushion up. Pull the cushion forwards. Then

17M8503478Point - applies to the S80 ● Press the centres of the clips at the bottom of the folding side panel on the right-hand side. Press the clips