1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Contents A comprehensive index is located at the back of this manual. Presentation In
1985 Volvo 740 GL, GLE, Turbo Bulb failure warning light The light will come on if any of the following bulbs are defective: one of the low beam hea
1985 Volvo 740 GL, GLE, Turbo pg. 90 Engine Compartment 740 Turbo (B230F-Turbo Engine) 1 Washer fluid reservoir 2 Expansion tank, coolant 3 Oil fill
1985 Volvo 740 GL, GLE, Turbo pg. 91 Engine OilChecking the oil level The oil level should be checked each time you refuel. Be sure the oil level is m
1985 Volvo 740 GL, GLE, Turbo WARNING! The oil may be very hot. To add or change engine oil Add oil of the same kind as already used. Capacity: 4.0 US
1985 Volvo 740 GL, GLE, Turbo SAE 15W/40 oil is recommended for use in severe driving conditions that increase oil consumption and raise oil temperatu
1985 Volvo 740 GL, GLE, Turbo manifold could alter air/fuel ratio and cause an increase in emissions and/or poor driveability.Valves The valve clearan
1985 Volvo 740 GL, GLE, Turbo 1 Battery 2 Injection control unit 3 Ignition control unit 4 Fuel filter 5 Fuel pump 6 Fuel feed pump 7 Air mass meter 8
1985 Volvo 740 GL, GLE, Turbo This is an emission control system designed to reduce emissions and improve fuel economy. An oxygen sensor monitors the
1985 Volvo 740 GL, GLE, Turbo The Intercooler Boost System The B230F-Turbo engine with the Intercooler Boost System employs a turbo-compressor to forc
1985 Volvo 740 GL, GLE, Turbo Crankcase ventilation The engines equipped with positive crankcase ventilation which prevents crankcase gases from being
1985 Volvo 740 GL, GLE, Turbo The spark plugs should be changed every 30,000 miles (50,000 km). However, city driving or fast highway driving may nece
1985 Volvo 740 GL, GLE, Turbo control unit. pg. 11 Starting (ignition) switch Starting (ignition) switch/steering wheel lock The steering wheel lock
1985 Volvo 740 GL, GLE, Turbo Rear axle Capacity: 1.7 US qts (1.6 liters) Oil type: API GL-5(MIL-L-2105 B or C). Viscosity: SAE 90 or 80W/90. Replace:
1985 Volvo 740 GL, GLE, Turbo CAUTION! Oil spilled on a hot exhaust pipe constitutes a fire risk. A Cold transmission: oil temperature +105°F (+40°C).
1985 Volvo 740 GL, GLE, Turbo Brake and clutch fluids (Note that some models have a clutch controlled by a cable.) The fluid reservoir serves both the
1985 Volvo 740 GL, GLE, Turbo No. Lubricating point Lubricant 1 Hood lock Paraffin wax 2 Hood hinges Oil 3 Door stop Oil4 Sunroof wind deflector O
1985 Volvo 740 GL, GLE, Turbo pg. 103 Cooling system Check coolant level The cooling system must be filled with coolant and not leak to operate at max
1985 Volvo 740 GL, GLE, Turbo Top up with coolant Top up with coolant by filling the expansion tank when level is at the "MIN" mark. Use a m
1985 Volvo 740 GL, GLE, Turbo belts or replace them if necessary. Contents | Top of Page file:///K|/ownersdocs/1985/1985_740_GL_GLE_Turbo/85740_07
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Specifications pg. 105 Specifications Dimensions and weights 740 GL, GLE 740 TURBO Le
1985 Volvo 740 GL, GLE, Turbo NOTE: When adding accessories, equipment, luggage and other cargo to your vehicle, the total loaded weight capacity of t
1985 Volvo 740 GL, GLE, Turbo 3 Model plate Vehicle Identification Number (VIN). Codes for color and upholstery etc. This plate is located on panel ab
1985 Volvo 740 GL, GLE, Turbo pg. 12 Turn signals, Hazard warning flasher Turn signals 1 Lane change position. In maneuvers such as lane changing, t
1985 Volvo 740 GL, GLE, Turbo Rear axle QualityAPI-GL-5 (MIL-L-2105 B or C) SAE 90 or 80W/90 Capacity1.7 US qts. (1.6 liters)Power steering Quality
1985 Volvo 740 GL, GLE, Turbo All specifications are subject to change without notice. 740 Turbo (B230F-Turbo engine) Liquid-cooled, gasoline, 4-cyli
1985 Volvo 740 GL, GLE, Turbo Capacity: 10 US qts (9.5 liters) Fuel system The engine is equipped with an electronic fuel injection system (type LH-J
1985 Volvo 740 GL, GLE, Turbo Ignition setting(cannot be adjusted) (12° B.T.D.C . at 900 rpm)Spark plugs: Volvo P/N 271409-5 0.024-0.028" (0.6-0
1985 Volvo 740 GL, GLE, Turbo 2nd gear 1.45:1 3rd gear 1:1 4th gear 0.69:1 Reverse 2.21:1 Rear Axle : Reduction ratios: 3.73:1Automatic transmissi
1985 Volvo 740 GL, GLE, Turbo Front end McPherson-type spring and strut suspension. Shock absorbers housed in strut casing. Rack-and-pinion steering.
1985 Volvo 740 GL, GLE, Turbo Bulbs Power Socket No. of bulbsFog lights 55 W H3 2License plate light 4 W W 2.1 x 9.5d 2Door warning lights 3 W
1985 Volvo 740 GL, GLE, Turbo washer fluid level 1.2 W Volvo P/N 966326 1Shift indicator 4th gear 1.2 W Volvo P/N 966326 1All specifications are subj
1985 Volvo 740 GL, GLE, Turbo Fuel tank (approx.) 15.8 US gal. 60 liters 15.8 US gal. 60 liters Cooling system 10 US qts. 9.5 liters 10 US qts. 9.5 l
1985 Volvo 740 GL, GLE, Turbo Volvo supports Voluntary Mechanic Certification by the N.I.A.S.E. Certified mechanics have demonstrated a high degree of
1985 Volvo 740 GL, GLE, Turbo rapidly than normal. 3 High beam/low beam switch (headlights on). Move the lever towards the steering wheel and release
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Index pg. 114-115 Specifications A Air conditioning 21, 22, 23 Air louvers 20 Alterna
1985 Volvo 740 GL, GLE, Turbo Chassis number 106 Checking coolant 103 Checking oil 91 Child safety 29 Child safety locks 33 Cigarette lighter 18 Clima
1985 Volvo 740 GL, GLE, Turbo Emergency towing (pulling) 48 Engine number 89-90 Engine 89-90Engine oil 91-92 F Fan belts 104 Fault Tracing 73 Federal
1985 Volvo 740 GL, GLE, Turbo Instrument lights 6 Instrument and controls 4 Interior light 27 J Jack 63 Jump start 50 K Keys 3 Kick-down 44 L Label in
1985 Volvo 740 GL, GLE, Turbo Parking lights 15 Polishing 83 Power steering fluid 101 Power train 110 R Radios 24 Rear axle oil 99 Rear foglights 16 R
1985 Volvo 740 GL, GLE, Turbo Temperature gauge 6 Tire pressure 59 Tires 57 Tire wear indicator 58 Tools 112 Touch up 80 Towing 49 Trailer hauling 53
1985 Volvo 740 GL, GLE, Turbo Wheels and tires 57 Window lifts 19 Windshield washers14 Windshield wipers 14 Winter driving 54 Wiper blades, replacemen
1985 Volvo 740 GL, GLE, Turbo file:///K|/ownersdocs/1985/1985_740_GL_GLE_Turbo/85740_09.htm (8 of 9)12/30/2006 7:46:13 AM
1985 Volvo 740 GL, GLE, Turbo Contents | Top of Page file:///K|/ownersdocs/1985/1985_740_GL_GLE_Turbo/85740_09.htm (9 of 9)12/30/2006 7:46:13 AM
1985 Volvo 740 GL, GLE, Turbo Cruise control (optional) The cruise control switches are located on the turn signal switch lever. To engage and set des
1985 Volvo 740 GL, GLE, Turbo WARNING! The cruise control should not be used in heavy traffic or when driving on wet or slippery roads. In case the g
1985 Volvo 740 GL, GLE, Turbo 5 Windshield wiper/washer.The wiper will make 2-3 complete sweeps after the lever is released. Adjusting washer nozzles
1985 Volvo 740 GL, GLE, Turbo Headlights and position lights All lights off Parking lights on Headlights and parking lights are on if starting (ig
1985 Volvo 740 GL, GLE, Turbo Rear fog lights The rear fog lights are considerably brighter than the normal tail lights and should be use only when at
1985 Volvo 740 GL, GLE, Turbo Rear window demister To operate, depress the switch. The indicator lamp in the switch will come on. The system will be s
1985 Volvo 740 GL, GLE, Turbo This Owner's manual provides information on driving and maintaining your Volvo It should be noted that there are c
1985 Volvo 740 GL, GLE, Turbo Parking brake (hand brake) The lever is situated between the front seats. The brake is applied to the rear wheels. Alw
1985 Volvo 740 GL, GLE, Turbo Ash trays To remove the ash trays depress the center spring and remove. pg. 19 Electrically operated windows Electrical
1985 Volvo 740 GL, GLE, Turbo Cut-out switch for electrically-operated rear-door windows If the car is equipped with rear door power windows, this fun
1985 Volvo 740 GL, GLE, Turbo Depending on which function you select, warm or cool/cold air is distributed to the different parts of the passenger com
1985 Volvo 740 GL, GLE, Turbo NOTE: A certain amount of air will always enter through the dash air louvers as long as they are open, independent of th
1985 Volvo 740 GL, GLE, Turbo pg. 22 Heating and ventilation Heating and ventilation system with air conditioning Air distribution file:///K|/owne
1985 Volvo 740 GL, GLE, Turbo NOTE: A certain amount of air will always enter through the dash air louvers as long as they are open; independent of t
1985 Volvo 740 GL, GLE, Turbo Additional information and tips ● The air conditioning compressor is engaged only if the temperature is above 46°F (
1985 Volvo 740 GL, GLE, Turbo Because of the limited range of FM signals and the way FM waves are spread, this problem can occur with FM reception. Mo
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Body and interior pg. 25 Body and interior The seats, seat belts, doors, etc. are des
1985 Volvo 740 GL, GLE, Turbo Write the key numbers on the inside of the front cover of this manual as well as your pocket diary. These number codes a
1985 Volvo 740 GL, GLE, Turbo Rear-view mirror A Normal position B Night position, reduces glare from following headlights Manually operated side vie
1985 Volvo 740 GL, GLE, Turbo The sun roof can be used in two ways: as a conventional sliding roof, or the rear edge can be raised or lowered to provi
1985 Volvo 740 GL, GLE, Turbo Height adjustment The front section of the driver's seat can be adjusted to three height positions and the rear sec
1985 Volvo 740 GL, GLE, Turbo pg. 29 Child safety Child safety Volvo recommends the proper use of restraint systems for all occupants including childr
1985 Volvo 740 GL, GLE, Turbo Two lights will be illuminated for 4-8 seconds after the starting (ignition) key is turned to the driving position. One
1985 Volvo 740 GL, GLE, Turbo ● the lap belt must be positioned low (not pressing against the abdomen). Make sure that the shoulder belt is rolled
1985 Volvo 740 GL, GLE, Turbo During pregnancy Pregnant women should always wear seat belts. Remember that the belt should always be positioned in su
1985 Volvo 740 GL, GLE, Turbo CAUTION! The lock buttons should not be in the down position during driving. In case of an accident, this may hinder rap
1985 Volvo 740 GL, GLE, Turbo A The door lock functions normally. B The door cannot be opened from the inside. Normal operation from outside. Remembe
1985 Volvo 740 GL, GLE, Turbo pg. 34 Trunk, Long load storage Long load storage In the panel behind the rear seat is a door which makes it possible
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Instruments and controls pg. 4 Instruments, Switches and controls pg. 5 Instruments,
1985 Volvo 740 GL, GLE, Turbo Trunk light A Light always off. B Light is on when trunk lid is opened. WARNING! When braking rapidly the load could be
1985 Volvo 740 GL, GLE, Turbo To open the hood Pull the release handle (located under the left side of the dash). Lift the hood slightly, insert a ha
1985 Volvo 740 GL, GLE, Turbo Engine compartment light A the light is always off B the light comes on when the hood is opened. pg. 36 Storage spaces
1985 Volvo 740 GL, GLE, Turbo CAUTION! Packages on the rear window shelf can obscure vision and may become dangerous projectiles in the even of a sudd
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Starting and driving pg. 37 Starting and driving. Break-in period This section on sta
1985 Volvo 740 GL, GLE, Turbo Manual transmission Do not exceed following speeds:* First 600 miles(1,000 km) 600-1,200 miles(1,000-2,000 km)Gear mph
1985 Volvo 740 GL, GLE, Turbo economy with gasohol, you should discontinue its use. Take care not to spill gasoline during refueling. Gasolines contai
1985 Volvo 740 GL, GLE, Turbo ● On cars with manual transmission, utilize the shift indicator light (S.I.L.). See "Instruments". Other f
1985 Volvo 740 GL, GLE, Turbo operating temperature as soon as possible. This is best achieved by driving with a light foot on the accelerator pedal f
1985 Volvo 740 GL, GLE, Turbo The overdrive is automatically disengaged when downshifting from 4th gear, but you should always disengage the overdrive
1985 Volvo 740 GL, GLE, Turbo 8 Heating and ventilation 20 9 Radio receptacle24 10 Cigarette lighter18 11 Ash tray 18 12 Electrically-heated passenger
1985 Volvo 740 GL, GLE, Turbo AW71 transmission (Turbo models) ZF transmission (GL, GLE models) Gear selector positions P park R reverse N neutral D
1985 Volvo 740 GL, GLE, Turbo D is the normal driving position. Upshifts and downshifts of the forward gears occur automatically and are governed by a
1985 Volvo 740 GL, GLE, Turbo Shift gate: AW71 transmission (Turbo models) The gear selector can be moved freely between D and 2. Selections of other
1985 Volvo 740 GL, GLE, Turbo 4th gear disengagement: AW71 transmission(Turbo models) The 4th gear is engaged automatically after the transmission has
1985 Volvo 740 GL, GLE, Turbo pg. 45 Automatic transmissionStarting and stopping a car equipped with automatic transmission 1. Fasten the seat belts.
1985 Volvo 740 GL, GLE, Turbo pg. 46 Points to remember Cooling system The risk for overheating is greatest, especially in hot weather, when: ● to
1985 Volvo 740 GL, GLE, Turbo WARNING! Do not drive with trunk lid or tailgate open! Poisonous exhaust gases may enter via the open trunk lid or tailg
1985 Volvo 740 GL, GLE, Turbo ● Place heavier cargo at the bottom of load. ● Observe that center of gravity and handling are influenced by loa
1985 Volvo 740 GL, GLE, Turbo pg. 50 Jump starting CAUTION: Improper hook-up of jumper cables or use of other than 12-volt batteries could result
1985 Volvo 740 GL, GLE, Turbo Check that cars are not touching to prevent premature completion of negative circuit. Note position of the battery term
1985 Volvo 740 GL, GLE, Turbo NOTE: Canadian model speedometers/odometers indicate kilometers only.1 Voltmeter (Turbo models) 2 Fuel gauge 3 Clock re
1985 Volvo 740 GL, GLE, Turbo ● Do not park your car over combustible materials, such as grass or leaves, which can come into contact with the hot
1985 Volvo 740 GL, GLE, Turbo without the engine running the brake pedal pressure required to stop the car is increased by 3-4 times. The brake pedal
1985 Volvo 740 GL, GLE, Turbo All Volvo models are equipped with energy-absorbing shock-mounted bumpers. Trailer hitch installation should not interfe
1985 Volvo 740 GL, GLE, Turbo ● Try to keep the fuel tank well filled-this prevents the formation of condensation in the tank. In addition to extr
1985 Volvo 740 GL, GLE, Turbo If you prefer to check the car yourself, please note the following: ● Check that engine runs smoothly and that fuel
1985 Volvo 740 GL, GLE, Turbo fuse number 5 to disconnect it. See "Fuses" section. ● Lift the wiper arms away from the windshield. ●
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Wheels and tires pg. 57 Wheels and tires The handling and riding comfort of the vehic
1985 Volvo 740 GL, GLE, Turbo Wear indicator The tires have a so-called "wear indicator" in the form of a number of narrow strips running ac
1985 Volvo 740 GL, GLE, Turbo chafe against the brake caliper or other components. Strap-on emergency chains must not be used since the clearance betw
1985 Volvo 740 GL, GLE, Turbo Contents | Top of Page file:///K|/ownersdocs/1985/1985_740_GL_GLE_Turbo/85740_04.htm (4 of 4)12/30/2006 7:46:08 AM
1985 Volvo 740 GL, GLE, Turbo The turbo engine is equipped with an rpm-limiter system; at engine speeds above approx. 6200 rpm, excessive misfiring wi
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo In case of emergency pg. 60 In case of emergency Even if you maintain your car in goo
1985 Volvo 740 GL, GLE, Turbo WARNING! Current legislation prohibits the use of the "Special Spare" tire other than as a temporary replaceme
1985 Volvo 740 GL, GLE, Turbo NOTE: To avoid excessive wear and the necessity of rebalancing, mark and reinstall wheels in same location as before rem
1985 Volvo 740 GL, GLE, Turbo clockwise and tighten lightly. The bevelled side of the nuts should face the wheel. Lower the vehicle to the ground and
1985 Volvo 740 GL, GLE, Turbo Installation is done by reversing the procedure. Check headlight alignment. pg. 65 Replacing bulbs Replacing bulbs, f
1985 Volvo 740 GL, GLE, Turbo pg. 66 Replacing bulbs Replacing tail lamp bulbs All tail lamp bulbs are replaced from inside of trunk. 1. Unscrew a
1985 Volvo 740 GL, GLE, Turbo 2 Back up light 32 (21) BA 15s 1073 3 Rear turn signal 32 (21) BA 15s 1073 4 Rear foglamp 32 (21) BA 15s 10735
1985 Volvo 740 GL, GLE, Turbo Engine compartment light Insert a screwdriver and pry off the light assembly. Lift it out to remove. Replace the bulb. B
1985 Volvo 740 GL, GLE, Turbo Interior light and reading lights Take hold of the front section of the light as shown and pull straight down. Replace
1985 Volvo 740 GL, GLE, Turbo NOTE: Do not touch bulb glass with fingers. Grease or oil can damage reflector when heated. Fuse replacement A blown fus
1985 Volvo 740 GL, GLE, Turbo for inspection. The warning light for boost pressure illuminates when the gauge pointer moves into the red section. pg.
1985 Volvo 740 GL, GLE, Turbo If you find it difficult to obtain access to the fuses, unclip the fuse tool on the right-hand side of the fuse compartm
1985 Volvo 740 GL, GLE, Turbo 9 Warning light, Seat belt, Turn signals, Air conditioning, Heated front seats, Electric cooling fan, Electrically-opera
1985 Volvo 740 GL, GLE, Turbo Lift the wiper arm off the windshield and hold blade at right angles to arm. Pinch the end of the plastic clip located a
1985 Volvo 740 GL, GLE, Turbo Weak battery or dead cell.With the starting (ignition) switch in the "Driving" or "On" position, che
1985 Volvo 740 GL, GLE, Turbo Rest pressure incorrectTest rest pressure and the fuel system for leaks.* If no fault is found following the steps abov
1985 Volvo 740 GL, GLE, Turbo pg. 76 Service diagnosis Condition: Low top speed, loss of powerPossible cause CorrectionAir filter clogged. Check air
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Car care pg. 77 Car care Car care includes not only maintaining the appearance of the
1985 Volvo 740 GL, GLE, Turbo 2. Corrosion will be accelerated in areas of higher relative humidity, especially where temperatures often stay above th
1985 Volvo 740 GL, GLE, Turbo a. thin (ML), for seams under the car. b. thin (transparent) for visible pans. c. thick, for parts on the underbody and
1985 Volvo 740 GL, GLE, Turbo Paint touch-up Paint damage requires immediate attention to avoid rusting. Make a habit of checking the finish regularly
1985 Volvo 740 GL, GLE, Turbo pg. 9 Warning lights The warning lights described on this page should never stay on when driving When the ignition key
1985 Volvo 740 GL, GLE, Turbo Apply the rust remover. (Avoid contact with eyes and skin!) Wait a few minutes and then rinse carefully with water and w
1985 Volvo 740 GL, GLE, Turbo 3 If there is a longer scratch, you may want to protect surrounding paint by masking it off. Touching up damaged paint o
1985 Volvo 740 GL, GLE, Turbo Washing the car The car should be washed at regular intervals since dirt, dust, insects and tar spots adhere to the pai
1985 Volvo 740 GL, GLE, Turbo NOTE: When washing the car, remember to remove dirt from the drain holes in the doors and sills. pg. 83 Automatic car
1985 Volvo 740 GL, GLE, Turbo winter. After the car has been washed, apply wax or an anti-rust preparation. Stains on chrome trim can be removed with
1985 Volvo 740 GL, GLE, Turbo 1 9 8 5 VOLVO 740 GL, GLE, Turbo Volvo Service pg. 85 Service - an investment! An investment which will pay dividends
1985 Volvo 740 GL, GLE, Turbo A= Adjust (Correct if necessary) R= Replace I= Inspect (Correct or Replace if necessary) L= Lubricate Maintenance Operat
1985 Volvo 740 GL, GLE, Turbo Chart provided with your vehicle. pg. 87 Servicing 1985 MAINTENANCE SCHEDULE 740A= Adjust (Correct if necessary) R=
1985 Volvo 740 GL, GLE, Turbo The following items should be checked weekly by the driver (it takes only a few moments): Engine oil level Brake fluid
1985 Volvo 740 GL, GLE, Turbo The Federal Clean Air Act (USA) The Clean Air Act requires vehicle manufacturers to furnish written instructions to the
Comments to this Manuals