1977 Volvo 262 264 2651 9 7 7 VOLVO 262 264 265Notice to Owner: Your Volvo has been built to comply with all North American safety and anti-pollution
1977 Volvo 262 264 265 open. The buzzer goes off when the front door is closed. Parking brake (hand brake) The lever is situated between the front s
1977 Volvo 262 264 265Fan belts 49Fault tracing 75Federal Clean Air Act 41Fresh air controls 15Front seats 18Front wheel alignment 84Frozen locks 22Fu
1977 Volvo 262 264 265Jack 66, 85K Keys 3Kick-down 35L License plate lights 63Light 9Limited slip differential 57Locks 22Long distance trips 72Lubrica
1977 Volvo 262 264 265Rear view mirrors 25Rear window heating 13Rust protection 69S Seat belts 20Seats 18Service diagnosis 75Servicing 41Shift positio
1977 Volvo 262 264 265Trailer hauling 38Transmission oils 56Trunk, 262, 264 23Turn signals 10Type designations 80U Upholstery, cleaning 69V Vehicle Id
1977 Volvo 262 264 265Tire pressures Contents | Top of Page file:///K|/ownersdocs/1977/1977_262_264_265/77262264265_05.htm (7 of 7)12/22/2006
1977 Volvo 262 264 265 Headlights and parking lights All lights off Parking lights on Headlights and parking lights onSwitch from upper to lower beam
1977 Volvo 262 264 265 pg. 10 Turn signals Turn signals 1 Signal lever engaged for normal turns. 2 Lane change position. In maneuvers such as lane c
1977 Volvo 262 264 265 Wiper/washer 1 "Single stroke" position. Switch returns automatically when released. 2 Wipers, low speed 3 Wipers,
1977 Volvo 262 264 265 Clock To reset the hands, push in the reset knob and turn. Cigarette lighter To operate, depress the knob fully. When the knob
1977 Volvo 262 264 265 1 Electrically operated window winder (Grand Luxe) 0 Off 1 Window down 2 Window up pg. 13 Tail gate window wiper, el. heated r
1977 Volvo 262 264 265 2 Tail gate wiper only.The fluid reservoir is located in the concealed storage area under the floor on the right side of the re
1977 Volvo 262 264 265 Heating system 1 TEMP Left = cool Right = warm 2 FLOOR Out = no air to floor In = full flow of air to floor 3 DEF (Defrost) Out
1977 Volvo 262 264 265 2 FLOOR depressed5 FAN >>> 2(or 3)6 All outlets halfway open. . . remove condensation 1 TEMP >>>WARM3 DEF dep
1977 Volvo 262 264 265 pg. 16 Air conditioning Air conditioning How to use the air conditioner: 1 FAN Position 3 for rapid cooling. The A/C does not
1977 Volvo 262 264 265Interior light, sun roof, fuel tank cap 26Rear seat, model 265 27Tail gate, model 265 28START AND DRIVINGBreaking in 31Starting
1977 Volvo 262 264 265 This page left intentionally blank.pg. 18 Front seats Horizontal seat adjustment Seat inclination adjustment file:///K|/ow
1977 Volvo 262 264 265Lumbar support adjustment pg. 19 Front seats Seat back release, 2-door models Press the button and fold forward. file:///K|/o
1977 Volvo 262 264 265Driver seat height There are two levers, each with three positions, for adjusting the height of the front or the back of the sea
1977 Volvo 262 264 265The front seats and the rear outboard seats are provided with retracting inertia belts. To buckle: Pull the belt slowly across y
1977 Volvo 262 264 265In these cases the belt should not be able to be pulled out. pg. 21 Seat belts Seat belts, manually adjustable The center rear
1977 Volvo 262 264 265pg. 22 Doors and locks Unlocking front doors Both front doors can be unlocked by using the key. Turning the key 1/4 turn counter
1977 Volvo 262 264 265In wintertime the door locks should be "lubricated" with a suitable agent to prevent freezing. If the lock is frozen,
1977 Volvo 262 264 265 pg. 24 Hood To open the hood Pull the release handle (located on the left side under the dash). Lift the hood slightly, insert
1977 Volvo 262 264 265Outside mirrors A Adjustment sideways B Adjustment up-down Inside view mirror D Normal position N Night position, reduces gla
1977 Volvo 262 264 265Interior light 1 Light always on. 2 Light always off. 3 Light is on when either of the front doors are opened. Model 265 may
1977 Volvo 262 264 265Service diagnosis 75Specifications 80Consumer Information 86Index 91pg. 2 General Information Before moving from one country or
1977 Volvo 262 264 265Filling fuel The gas cap is located behind the door on the right rear fender. When filling, position the cap in the special bra
1977 Volvo 262 264 265Pull up on either of the parallel-connected handles on the rear side of the seat back and fold the seat back forward and down so
1977 Volvo 262 264 265To open from the inside Pull out the T-handle located at the bottom of the tail gate. To close Push the catch upwards and at the
1977 Volvo 262 264 265Safety catch A The lid cannot be opened from the inside. B The lock functions normally. Spare wheel Remove the two thumb screws
1977 Volvo 262 264 2651 9 7 7 VOLVO 262 264 265 pg. 30 Service Inspection STARTING AND DRIVINGService Inspection To ensure proper operation the car
1977 Volvo 262 264 2653rd gear 60 mph (100 km/h) 4th gear 80 mph (130 km/h) 2 2) 90 mph (150 km/h) with overdrive engaged. Avoid driving at low speed
1977 Volvo 262 264 265This is achieved by driving with a light load as soon as possible. pg. 33 Gear shift positions 4-speed manual transmission wi
1977 Volvo 262 264 265Reversing inhibitor Lift the ring to enter the reverse gear. The ring locking mechanism prevents reverse gear from being engaged
1977 Volvo 262 264 265Depressing the selector knob slightly allows selection of positions N and 1. Depressing the selector knob fully allows selectio
1977 Volvo 262 264 265If position 1 is selected when driving at high speeds, 2 is engaged first and 1 when the speed has dropped to approx. 30 mph (50
1977 Volvo 262 264 265Write the key number codes in the spaces designated for this purpose on the second page of the cover. In the event the original
1977 Volvo 262 264 265 Precautionary steps. To observe when towing Steering must be unlocked. Observe legal speeds. ● Remember that power brake
1977 Volvo 262 264 265 pg. 38 Trailer hauling When preparing for trailer hauling, observe the following: ● Use an approved trailer hitch (availab
1977 Volvo 262 264 265● Use a sturdy roof rack, intended for the vehicle and rigidly attached. It is not advisable to let the roof rack remain in
1977 Volvo 262 264 265The brake pedal feels stiff and hard. If one of the brake circuits should malfunction the red warning light comes on (F page 6).
1977 Volvo 262 264 265● Keep your engine properly tuned. Certain engine malfunctions, particularly involving the electrical, fuel or ignition syst
1977 Volvo 262 264 2651 9 7 7 VOLVO 262 264 265 pg. 41 Maintenance services MAINTENANCEMaintenance services Your Volvo has passed two major inspec
1977 Volvo 262 264 265Fuel RON 91 Octane rating 91 For vehicles with catalytic converters unleaded fuel must be used. Vehicles not equipped with catal
1977 Volvo 262 264 265 1 Data plate 2 Compressor (Air conditioner) 3 Oil filler cap, engine 4 Air cleaner 5 Oil dipstick, automatic transmission 6 B
1977 Volvo 262 264 265A= Adjust (Correct if necessary) R= Replace I= Inspect (Correct or Replace if necessary) L= Lubricate Maintenance OperationMiles
1977 Volvo 262 264 265A= Adjust (Correct if necessary) R= Replace I= Inspect (Correct or Replace if necessary) L= Lubricate Maintenance OperationMiles
1977 Volvo 262 264 265 1 9 7 7 VOLVO 262 264 265 pg. 4 Instruments and controls pg. 5 Instruments and controls See page1 Fresh air outlet152 Tu
1977 Volvo 262 264 265A= Adjust (Correct if necessary) R= Replace I= Inspect (Correct or Replace if necessary) L= Lubricate Maintenance OperationMiles
1977 Volvo 262 264 265Windshield wipersLevel of windshield fluidThe following should also be carried out regular intervals. Description on pageWashing
1977 Volvo 262 264 265At temperatures below 0°F, multigrade oil SAE 5W-20 or SAE 5W-30 is recommended. However, this oil should not be used when the t
1977 Volvo 262 264 265The heater controls should be fully open when draining and filling. Add coolant until the level is up to the MAX mark or slight
1977 Volvo 262 264 265I Engine Mechanical ComponentsTorque manifold bolts The manifold bolts should be torqued at the 600 mile inspection. A loose man
1977 Volvo 262 264 265Fuel (line) filter The fuel filter is located on the firewall. This filter is to be changed every 30,000 miles. The filter is re
1977 Volvo 262 264 265Ignition timing Distributor advance mechanism The ignition timing should be adjust first time at the 600 mile inspection and af
1977 Volvo 262 264 265Instead, the crankcase gases are admitted to the intake manifold and cylinders. Cleaning PCV valve The calibrated positive crank
1977 Volvo 262 264 265Air Injection Reactor System This system admits fresh air to the hot exhaust gases in the exhaust manifold. The fresh air will b
1977 Volvo 262 264 265through channels in the insert. The channel walls are covered by a thin layer of platina-palladium. These metals act as catalyst
1977 Volvo 262 264 265 11 Fuse box 6412 Hood release handle 2413 Instrument lights 914 Electrically operated window winder, left front door 1215 Tail
1977 Volvo 262 264 265 Contents | Top of Page file:///K|/ownersdocs/1977/1977_262_264_265/77262264265_03a.htm (16 of 16)12/22/2006 10:08:30 PM
1977 Volvo 262 264 265 pg. 56 Transmission oil Manual 4-speed transmission with overdrive, M46 Capacity: 2.4 US qts = 2.3 liters Fluid type: Automati
1977 Volvo 262 264 265Automatic transmission Capacity: 7.0 US qts = 6.5 liters Fluid type: Automatic Transmission Fluid type F(FLM).Replace: no oil c
1977 Volvo 262 264 265Replace: at 600 miles only. The oil level should be up to the filler plug (A). Drain rear axle oil through drain plug (B). Wh
1977 Volvo 262 264 265Check, without removing the cap, that the level is above the "MIN" mark of the fluid reservoirs. Always entrust brake
1977 Volvo 262 264 265No. Lubricating point Lubricant1 Hood lock Paraffin wax2 Hood hinges Oil3 Sun-roof wind deflector Oil4 Door lock outer sliding
1977 Volvo 262 264 265percent anti-freeze/summer coolant and 50 percent water all the year round. Top up to the "Max" mark. If the engine is
1977 Volvo 262 264 265pg. 61 Replacing bulbs Replacing sealed beam headlamp units 1. Press the two plastic screws down and turn them 1/4 turn and rem
1977 Volvo 262 264 265 Power W/cpSocket US bulb No 1 Front position, side marker lights 262, 264, 265 5/4 Ba 15 s 672 Front turn signal 262, 264, 2
1977 Volvo 262 264 265pg. 63 Replacing bulbs License plate light Insert a screwdriver through the opening in the housing and depress the catch tab. P
1977 Volvo 262 264 265 J Trip odometer (last figure represents 1/10 mile/km) K Trip odometer reset knob Push in to reset L Reminder light, EGR Service
1977 Volvo 262 264 265Interior light Insert a screwdriver through the opening in the right side of the housing and depress the catch tab. Pull out the
1977 Volvo 262 264 2654 Glove compartment light, Back up lights, (El. heated seat), Air conditioning, Window lift 8A5 Instrument, Turn signals, Warnin
1977 Volvo 262 264 265Check tire pressure Check tire inflation pressure at regular intervals to avoid abnormal wear. The spare tire should also be che
1977 Volvo 262 264 265Removing The wheel cap can be removed with the tommy bar or the screwdriver provided in the tool kit. Loosen the wheel nuts 1/2
1977 Volvo 262 264 265 Be sure the arm goes all the way into the attachment. Raise up the side of the car enough to lift the wheel off the ground. Uns
1977 Volvo 262 264 265 pg. 68 Washing, cleaning Washing The car should be washed often as dirt, dust, insects and tar spots adhere firmly to the paint
1977 Volvo 262 264 265pg. 69 Cleaning Cleaning the upholstery Generally the fabric can be cleaned with soapy water or a detergent. For more difficult
1977 Volvo 262 264 265Minor stone chips and scratches Material: Rust remover Primer - brush on type Surface finish - brush on type (The paint pen head
1977 Volvo 262 264 2654 When the primer surface is dry, the paint can be applied using a brush. Mix the paint thoroughly, apply several thin paint coa
1977 Volvo 262 264 265Apply the rust remover (watch eyes and skin!), wait a few minutes and then rinse carefully with water. 3 Shake the spray can for
1977 Volvo 262 264 265 pg. 7 Warning lights The warning lights described on this page should never be on when drivingWhen the ignition key is turned o
1977 Volvo 262 264 265shown that extremely weak anti-freeze solutions (10-25 percent) are very unfavorable rust protection. For this reason, the quant
1977 Volvo 262 264 265This page left intentionally blank.pg. 75 Service diagnosis The diagnoses outlined below are intended to serve as a guide to loc
1977 Volvo 262 264 265Possible cause Correction Intake system leaking.Check hose connections to cold start valve and auxiliary air valve. No fuel rea
1977 Volvo 262 264 265Possible cause Correction Defective wires.Check wire terminals at: fuel pump, fuse No. 7, coil, distributor, ignition switch an
1977 Volvo 262 264 265 pg. 79 Service diagnosis Condition: Dieseling Possible cause Correction Injector leaking. Check air sensor plate and rest pr
1977 Volvo 262 264 2653 Model Plate Vehicle Identification Number (VIN), Version Identification Code (VIC) with information on engine type, emission e
1977 Volvo 262 264 2651 9 7 7 VOLVO 262 264 265 pg. 81 Specifications Dimensions and weights 262 264 265 Length 191.7" (487 cm) 191.7&qu
1977 Volvo 262 264 265Height 32.7" (83 cm) Volume with rear seat up 42 cu. ft.(1.2 m3)Volume with rear seat down 71 cu. ft.(2.0 m3)Cargo opening,
1977 Volvo 262 264 265Bore 3.46" (88 mm) Stroke 2.87" (73 mm) Displacement 2.66 liters Compression ratio 8.2:1 Valve clearance cold engine
1977 Volvo 262 264 26512 V, negative ground. Voltage-controlled alternator. Single-wire system with chassis and engine used as conductors. Voltage 1
1977 Volvo 262 264 265 L EGR service reminder light (red) If the vehicle is equipped with exhaust gas recirculation, this light will come on at 15,00
1977 Volvo 262 264 265Shift positions, Auto Transmission 1.2 W W 1.8d 1 Engine Compartment Light 15 W S 8.5 1 Trunk Light 15 W S 8.5 1 Warning La
1977 Volvo 262 264 265Front wheel alignment The alignment specifications apply to an unloaded car but include fuel, coolant and spare wheel. Toe-in :
1977 Volvo 262 264 265pg. 85 Specifications Recommended max. and min. speeds, mph (kmph) 1st gear 2nd gear 3rd gear 4th gear -30(-50) 15-53(20-85)
1977 Volvo 262 264 265in accordance with Federal requirements for comparison with other makes and models. The exacting test procedures established by
1977 Volvo 262 264 265 pg. 87 Customer information High speed The high speed pass assumes an initial speed of 50 mph and a limiting speed of 80 mph.
1977 Volvo 262 264 265 pg. 88 Customer information Vehicle Stopping Distance This chart indicates braking performance that can be met or exceeded by
1977 Volvo 262 264 265 pg. 89 Customer information Vehicle Stopping Distance This chart indicates braking performance that can be met or exceeded by
1977 Volvo 262 264 265Tire Reserve LoadThis chart lists the 1977 262, 264 and 265 tire designations recommended by Volvo with the recommended inflatio
1977 Volvo 262 264 2651 9 7 7 VOLVO 262 264 265 pg. Index A Acceleration and passing ability 86Air Conditioning 16Alternator, important note 60Anti
1977 Volvo 262 264 265Child safety locks 23, 29Cigarette lighter 12Clock 12Cold start 32Cold weather driving 73Consumer Information 86Control lights 6
Comments to this Manuals